PolyCast™
Last updated
Was this helpful?
Last updated
Was this helpful?
Issue date: 07/29/2019
Revision date: 07/29/2019 SDS record number: CSSS-TCO-010-132060
Product name PolyCast™
Synonyms -
CAS # See section 3
Product code -
Product use 3D Printing Filament
Manufacturer/Supplier
Supplier(Manufacturer): JF Polymers (Suzhou) Co., Ltd.
Address: Building 6&7&11, No.2, Hai Cheng Road, Chang Shu Economic & Technological Development Zone, 215513, People’s Republic of China
Contact person(E-mail): zhenggang.cai@polymaker.com
Telephone: +86-512-52058005
Fax: -
Emergency telephone Number: +86-512-52058005
GHS classification
Physical hazards deifissalc toN
Health hazards deifissalc toN
Environmental hazards deifissalc toN
GHS label elements
Hazard Pictograms No hazard pictogram is used.
Signal word No signal word is used.
Hazard statement Not applicable.
Precautionary statement
Prevention Not applicable.
Response Not applicable.
Storage Not applicable.
Disposal Not applicable.
This product does not contain hazardous ingredients above cut-off value according to HCS2012.
First aid procedures
Eye contact Flush with running water for at least 15 minutes. If irritation persists get medical attention.
Skin contact Wash thoroughly with soap and water. Get medical attention in the unlikely event that irritation persists.
Inhalation If breathed in, remove victim to fresh air and keep at rest in a position comfortable for breathing. If you feel unwell, seek medical attention.
Ingestion Immediate first aid is not likely to be required. A physician or poison control center can be contacted for advice.
Notes to physician Treat symptoms.
Flammable properties Not available.
Extinguishing media
Suitable extinguishing media Use water spray, alcohol resistant foam, dry powder or carbon dioxide to extinguish the fire.
Unsuitable extinguishing media Avoid using DC water to extinguish fire, so as to avoid material splashes and fire spread.
Firefighting equipment/instructions
In case of fire and/or explosion do not breathe fumes. Protective respirator with independent air supply. According to size of fire Full protection, if necessary.Dispose of contaminated extinction water according to official regulations.
Hazardous combustion products Carbon oxides, nitrogen oxides.
Accidental release measures
Personal precautions
Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Avoid contact with skin and eyes. For personal protection see section 8.
Environmental precautions Avoid disposing into drainage/sewer system or directly into the aquatic environment.
Methods for cleaning up Sweep up and shovel into suitable containers. Clean up affected area.
Handling Ensure good ventilation/exhaustion at the workplace. Wash thoroughly after handling.
Storage Store in cool place. Keep container tightly closed in a dry and well-ventilated place.
Occupational exposure limits This mixture has no ingredients that have PEL, TLV, or other recommended exposure limit.
Biological limit values No biological exposure limits noted for the ingredient(s).
Appropriate engineering controls: Use in a well-ventilated area.
Individual protection measures, such as personal protective equipment:
Eye / face protection Chemical safety goggles.
Skin protection Wear suitable protective clothing to prevent skin exposure
Respiratory protection Suitable respiratory protective device recommended.
General hygiene Wash hands, forearms and face thoroughly after handling chemical products,
considerations
before eating, smoking and using the lavatory and at the end of the working period. Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing.
Appearance
Physical state Solid
Form Solid
Color Translucent
Odor Odorless
Material name: PolyCast™ SDS US
Version #:1.0 Revision date: 07-29-2019. Issue date: 07-29-2019. 2 / 5
Odor threshold Not available
pH Not available
Vapor pressure Not available
Melting point/Freezing point Not available
initial boiling point and boiling range Not available
Flash point Not available
Evaporation rate Not available
Flammability (solid, gas) Not available
Explosion limits Not available
Vapor density Not available
Density 1.08-1.10
Solubility (water) Insoluble
Partition coefficient Not available
Auto-ignition temperature Not available
Decomposition temperature Not available
Specific gravity Not available
Flammability limits in air, upper, %by volume Not available
Flammability limits in air, lower, % by volume Not available
VOC Not available
Percent volatile Not available
Other data
Viscosity Not available
Upper/lower explosive limits Not available
Surface tension Not available
Chemical stability Material is stable under normal conditions.
Conditions to avoid Incompatible materials.
Incompatible materials Avoid contact with other chemicals, oxidizing agents, strong alkalis and strong acids.
Hazardous decomposition products Carbon oxides, nitrogen oxides.
Possibility of hazardous reactions No dangerous reactions known.
Toxicokinetics, metabolism and distribution:
Non-human toxicological data: Not available
Information on toxicological effects:
Acute toxicity:
LD50(Oral, Rat): Not available
LD50(Dermal, Rat): Not available
LC50(Inhalation, Rat): Not available
Skin corrosion/Irritation: Not classified.
Serious eye damage/irritation: Not classified
Respiratory or skin sensitization: Not classified
Germ cell mutagenicity: Not classified
Carcinogenicity: Not classified
Reproductive toxicity: Not classified
STOT- single exposure: Not classified
STOT-repeated exposure: Not classified
Aspiration hazard: Not classified
Toxicity:
EC50
N/A
72h
Fish
OECD 203
N/A
N/A
EC50
N/A
48h
Daphnia
OECD 202
N/A
N/A
EC50
N/A
72h
Algae
OECD 201
N/A
N/A
Persistence and degradability: Not available.
Bioaccumulative potential: Not available.
Mobility in soil: Not available.
Results of PBT&vPvB assessment: Not available.
Other adverse effects: No known significant effects or critical hazards.
Disposal instructions Dispose of contents/container in accordance with
local/regional/national/international regulations.
Contaminated packaging Since emptied containers may retain product residue, follow label warnings even after container is emptied.
DOT
Basic shipping requirements:
UN number Not regulated
Proper shipping name Not regulated
Hazard class Not regulated
Packing group Not regulated
Environmental hazards No
IATA
UN number Not regulated
UN proper shipping name Not regulated
Transport hazard class(es) Not regulated
Packing group Not regulated
Environmental hazards No
IMDG
UN number Not regulated
UN proper shipping name Not regulated
Transport hazard class(es) Not regulated
Packing group Not regulated
Environmental hazards No
US federal regulations
Toxic Substances Control Act (TSCA)
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
.detaluger toN
CERCLA Hazardous Substance List (40 CFR 302.4)
.detsil toN
SARA 304 Emergency release notification
.detaluger toN
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
.detaluger toN
Superfund Amendments and Reauthorization Act of 1986 (SARA)
SARA 302 Extremely hazardous substance
.detsil toN
SARA 311/312 Hazardous chemical No
SARA 313 (TRI reporting)
Not regulated.
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Safe Drinking Water Act (SDWA) Not regulated.
Other information, including date of preparation or last revision
HMIS®ratings Health: 0
Flammability: 1
Physical hazard: 0
NFPA ratings Health: 0
Flammability: 1
Instability: 0
Disclaimer The information in the sheet was written based on the best knowledge and experience currently available.
Issue date 07-29-2019
Author: Hangzhou C&K Testing Technic Co.,Ltd Website:www.cirs-ck.com Tel:0571-89900715 Email:test@cirs-group.com
